OPTIMALISASI STABILITAS PADA LAPIS ASPAL BETON DENGAN MENGGUNAKAN AGREGAT LIMBAH BETON

Aldo Verdiawan; Andri Dwi Cahyono; Evita Fitrianis Hidiyati; Aldo Riki Saputra; Rizky Hary Anto; Anggik Fatkhurrokhman; Mochammad Munhamir; Muhammad Bagus Maulana; Rendy Kurnia Dewanta

doi:10.36341/racic.v8i2.3200

Aldo Verdiawan Kadiri University
Andri Dwi Cahyono Universitas Kadiri
Evita Fitrianis Hidiyati Universitas Kadiri
Aldo Riki Saputra Universitas Kadiri
Rizky Hary Anto Universitas Kadiri
Anggik Fatkhurrokhman Universitas Kadiri
Mochammad Munhamir Universitas Kadiri
Muhammad Bagus Maulana Universitas Kadiri
Rendy Kurnia Dewanta Universitas Kadiri

: https://doi.org/10.36341/racic.v8i2.3200

Abstract

Concrete waste is waste material produced during the construction, renovation or demolition of concrete. The waste comes from residential areas that were evicted or demolished so that the airport land becomes sterile. The negative effects of the development, the large amount of concrete waste due to demolition and the absence of innovation in handling concrete waste. Therefore, utilizing concrete waste as a substitute for coarse aggregate in making marshal samples for asphalt road planning. so this research using materials from recycling rca concrete is very meaningful to determine which type of pavement to be used in the research. Therefore, to overcome these problems, the method used in this research is SNI 06- 2489- 1991 Procedures for Testing Asphalt Combinations with Marshall Equipment. By using RCA Waste coarse aggregate on the constituent materials of AC-BC concrete layer obtained an average stability result of 4843 kg. It is expected that these results are suitable for use as material to replace coarse aggregate on road pavements in accordance with the provisions of the 2018 bina marga specification.

Keywords: Keywords: aggregate, RCA, Marshall, stability,, aggregate, RCA, Marshall, stability,

References

N. Imannurrohman, “Pemanfaatan Limbah Beton Sebagai Pengganti Agregat Kasar Pada Perkerasan Laston Asphalt Concrete – Wearing Coarse (Ac-Wc),” J. Rekayasa Infrastruktur Sipil, vol. 2, no. 1, p. 25, 2021, doi: 10.31002/.v1i2.3406.

S. Fitri, S. M. Saleh, and M. Isya, “Pengaruh Penambahan Limbah Plastik Kresek Sebagai Subsitusi Aspal Pen 60/70 Terhadap Karakteristik Campuran Laston Ac – Bc,” J. Tek. Sipil, vol. 1, no. 3, pp. 737–748, 2018, doi: 10.24815/jts.v1i3.10034.

R. Rachman, “Karakteristik Campuran Laston Lapis Aus yang Menggunakan Agregat Limbah Beton,” J. Tek. Sipil UKIPaulus-Makassar Vol. 3 Issue 3, Sept. 2021, vol. 3, no. 3, pp. 459–468, 2021.

F. Hasan, S. M. Saleh, and R. Anggraini, “Dampak Substitusi Filter Rokok Ke Dalam Aspal Penetrasi 60/70 Terhadap Karakteristik Marshall Laston,” J. Tek. Sipil, vol. 1, no. 3, pp. 593–604, 2018, doi: 10.24815/jts.v1i3.9998.

M. Mardiansah, V. T. Haris, and F. Lubis, “Analisis Kehilangan Kadar Aspal pada Aspal Buton untuk Campuran Laston Lapis Antara (AC-BC),” J. Tek., vol. 12, no. 2, pp. 97–104, 2018, doi: 10.31849/teknik.v12i2.1889.

G. W. Subagyo, “Kinerja Modulus Resilien Campuran Beraspal Panas Asphalt Concrete Binder Course (AC-BC) Yang Mengandung Recycled Concrete Aggregate,” Widyakala J. Pembang. Jaya Univ., vol. 7, no. 1, p. 1, 2020, doi: 10.36262/widyakala.v7i1.224.

D. Nuralinah, D. Setyowulan, and E. Arifi, “Pengaruh Variasi Agregat Kasar Daur Ulang ( Rca ) Terhadap Kuat Lentur Balok Beton Self Compacting Concrete ( Scc ) Bertulangan Baja,” 2018.

L. Andrianingsih, N. P. Artiwi, and A. S. Huda, “Analisis Pengujian Kuat Tekan Campuran Aspal Beton (Laston Ac-Wc) Dengan Parafin,” J. Sustain. Civ. Eng., vol. 4, no. 01, pp. 42–50, 2022, doi: 10.47080/josce.v4i01.1830.

A. B. Ansori, “Pengaruh Mutu Limbah Beton Sebagai Bahan Substitusi Agregat Kasar Pada Kualitas Campuran Asphalt Concrete-Binder Coarse (Ac-Bc),” J. Konstr., no. Vol 9, No 1 (2017): Jurnal Konstruksia Vol 9 No. 1 Tahun 2017, pp. 1–14, 2017.

A. Gasruddin, “Pemanfaatan Limbah Beton Sebagai Agregat Kasar Pada Aspal Berongga Menggunakan Aspal Penetrasi 60/70,” J. Media Inov. Tek. Sipil Unidayan, vol. 8, pp. 70–80, 2019.

H. Mashuri, A. Ridwan, A. I. Candra, and F. M. Azhari, “Research Of Porous Concrete With Master Ease 5010 Mixed And Additional Rude Aggregate From Kedak Region,” J. Tek. Sipil Univ. Islam Lamongan, vol. 6, no. 1, pp. 83–96, 2021.

M. F. S. Mochamad Rizki F.U, Agata Iwan Candra, Evita Fitrianis Hidiyati, Dikhy Ridho Laksono, Ramadhan Mahendra, Muhammad Lutfi Amzari, Mukhammad Ibnul Mubarok, “Classify Aggregates in Asphalt Pavement Layers (Ac-Bc) using Sieve Shaker,” vol. 6, no. 1, pp. 21–31, 2022.

M. Campuran, L. Aspal, and B. Laston, “PENGARUH PENGGUNAAN LIMBAH BOTOL PLASTIK TERHADAP KARAKTERISTIK,” vol. 15, pp. 77–84, 2022.

Y. Tabi, R. Rachman, and Alpius, “Durabilitas Campuran Laston Lapis Aus Menggunakan Agregat Limbah Beton,” Paulus Civ. Eng. J., vol. 4, no. 2, pp. 339–345, 2022, doi: 10.52722/pcej.v4i2.464.

M. Induwati et al., “Identifikasi Karakteristik Agregat Terhadap Nilai Stabilitas Lapis Perkerasan Aspal Beton AC-BC ( Laston ) berkualitas maka perlu diberikan teknologi penanganan yang bernilai ekonomis menurun . Turunnya nilai stabilitas tersebut disebabkan oleh air yang menembus,” vol. 13, no. 1, pp. 193–206, 2023.